GovWire

Once you register with the Pig Carcase Grading Scheme, you must follow the rules that describe how to:

• dress carcases
• weigh carcases
• grade carcases for lean meat content (the grade is then marked on the carcase or documented)

There are also rules about the information you must record for each carcase.

Dress carcases

You must dress pig carcases according to either the EU or the UK dressing specification. You cannot use your own dressing specification.

The EU specification

Before weighing the carcase, you must remove the:

• tongue
• bristles (hair)
• hooves
• genital organs
• flare fat
• kidney
• diaphragm

The UK specification

In the UK, abattoirs are allowed to present pig carcases according to the UK specification.This means dressing carcases the same as EU specification, but leaving the following parts in:

• kidneys
• flare fat
• diaphragm

You can leave the tongue in or take it out.

Sticking wound

The removal of the sticking wound is required for health and hygiene reasons to remove the contamination caused during the sticking process, as set out in (EU) 2019/627, Article 45 point (D). The removal of the sticking wound must be undertaken ensuring that associated skin, fat and flesh that is not part of the contaminated area remains attached to the carcase.

Weigh carcases

You must record carcase weights as they appear on the actual scale display. You must not round the weight up or down.

You must weigh the dressed carcase for its warm weight. Wherever possible, you must do this no more than 45 minutes after the pig has been stuck.

The table below shows the adjustments (also known as coefficients) that you must make to the weight displayed on the scale to arrive at a standardised warm weight when the presentation of the carcass differs from the standard specification set out in retained EU legislation.

To calculate the cold weight, deduct 2% from the warm weight. Any deductions from the table above must be applied before the 2% is taken.

Example:A carcass with kidneys, flare fat, diaphragm and tongue in has a scale weight of 65kg. 1.4kg is first deducted per the table above to reach a standardised warm weight of 63.6kg. 2% is then deducted, for a cold weight of 62.3kg (rounded to 0.1kg).

Should there be a delay of more than 45 minutes between when the pig is stuck and when it is weighed, the 2% deduction must diminish by 0.1% for every 15 minutes or part thereof of delay beyond the first 45 minutes. For example, in the case of a pig that is weighed 85 minutes after being stuck, the warm-cold coefficient should be 1.7%.

Grade carcases

• Intra-scope (Optical Probe)
• Fat-O-Meater (FOM)
• Hennessy Grading Probe (HGP II)
• CSB Ultra-Meater
• AutoFom (fully automatic ultrasonic carcase grading)

The results must then be used to grade the carcase according to this scale:

Record carcase grades

You must mark information about the carcase grade directly on to the carcase or record it at the time of grading.

You must mark carcases destined for export uncut to an EU member state with either:

• the appropriate letter from the grading scale above; or
• the percentage lean meat content.

In other cases, you must either:

• mark the carcase with the appropriate letter from the grading scale or with the percentage lean meat content; or
• keep a record for each carcase containing at least
  • the individual identification of the carcase by any unalterable means
  • the warm weight of the carcase, and
  • the EU classification letter from the grading scale above.

If you mark the carcase, you must use indelible, non-toxic, heat-resistant ink and the letters and numbers must be at least 2 centimetres high.

Communicate the classification results

You must tell whoever has sent the animal to slaughter the results of the classification, either in writing or electronically. The format you use could be an invoice or attached document.

You must tell them:

• which dressing specification has been used
• the classification results (EU class)
• the carcases weight (specifying whether this is the warm weight or the cold weight).